Welcome to the Hatteras Owners Forum & Gallery. Sign Up or Login

Enter partial or full part description to search the Hatteras/Cabo parts catalog (for example: breaker or gauge)
+ Reply to Thread
Page 1 of 2 1 2 LastLast
Results 1 to 10 of 14
  1. #1

    A/C Condenser Compressor cycles quickly....

    I'm sure this question has been asked a thousand times, but I have to ask again as I have a HVAC tech coming out in next couple of days to look at.

    I just launched boat few days ago and tested out systems, including A/C system. The compressor on a 10 year old Dometic R22 16,000 BTU condenser is cycling on for about 3-7 seconds, then shuts off for about 10 - 20 seconds, then on again for 3-7 seconds, repeat. Does this wether in heating or cooling mode (with temp set to activate compressor in each mode, appropriately). I'm assuming it's going off on the low pressure switch and needs a charge (not charged since replaced 10 years ago). I don't see a capacitor to start the compressor, but could be hidden. Guessing it could be that too but it does sound like compressor is actually running for those 3-7 seconds, which if is the case, not the capacitor. What do you guys think is causing the compressor cycling?
    Scott
    1976 43DCFB ,Hull #428, “Exodus”
    Long Island, NY

  2. #2

    Re: A/C Condenser Compressor cycles quickly....

    Check water flow. Probably #1 reason for short cycling as head pressures trip the HP switch

  3. #3

    Re: A/C Condenser Compressor cycles quickly....

    How is the water flow? What controls do you have ?

    If it was tripping on low or high pressure, it wouldn’t restart and cycle indefinitely. Some controls allows for a couple of errors and restart before shutting down.
    Pascal
    Miami, FL
    1970 53 MY #325 Cummins 6CTAs
    2014 26' gaff rigged sloop
    2007 Sandbarhopper 13
    12' Westphal Cat boat

  4. #4

    Re: A/C Condenser Compressor cycles quickly....

    Waterflow looks good, although the raw water pump is t'd off to two separate 16,000 BTU condensers which then discharge into a single discharge sea chest. So perhaps I should put a pair of vice crips on hose to good unit (which I'll leave off) and see if water still coming out as it would be forced through unit in question only. I did not realize these condensers had water flow switches. It seems impossible to find a parts diagram for them, guessing they do a good job of protecting their dealers. Anybody know where the waterflow switch is located on these (Dometic / Marine Air Specialist model CSM16K/1, Serial Number: 82599251) so that I can check out switch operation if waterflow looks good?

    The controls are Coastal Climate FX-1. Been working great for about 5 years now.
    Last edited by sgharford; 05-22-2023 at 11:22 AM.
    Scott
    1976 43DCFB ,Hull #428, “Exodus”
    Long Island, NY

  5. #5

    Re: A/C Condenser Compressor cycles quickly....

    Quote Originally Posted by sgharford View Post
    Waterflow looks good, although the raw water pump is t'd off to two separate 16,000 BTU condensers which then discharge into a single discharge sea chest. So perhaps I should put a pair of vice crips on hose to good unit (which I'll leave off) and see if water still coming out as it would be forced through unit in question only. I did not realize these condensers had water flow switches. It seems impossible to find a parts diagram for them, guessing they do a good job of protecting their dealers. Anybody know where the waterflow switch is located on these (Dometic / Marine Air Specialist model CSM16K/1, Serial Number: 82599251) so that I can check out switch operation if waterflow looks good?

    The controls are Coastal Climate FX-1. Been working great for about 5 years now.
    Most of them don't have flow switches, but all of them have high pressure switches that will almost immediately trigger and shut the unit down when the compressors kicks on without cooling water. Same difference really.

  6. #6

    Re: A/C Condenser Compressor cycles quickly....

    Pull the hose off the sea chest and put it in a bucket to check for flow.

    I doubt these have water flow switches. I know chillers have them on the chilled water loop and they can be a pita. On regular condensers the high pressure switches will trip as soon as pressure gets too high and will prevent damage.
    Last edited by Pascal; 05-22-2023 at 04:45 PM.
    Pascal
    Miami, FL
    1970 53 MY #325 Cummins 6CTAs
    2014 26' gaff rigged sloop
    2007 Sandbarhopper 13
    12' Westphal Cat boat

  7. #7

    Re: A/C Condenser Compressor cycles quickly....

    Not the water flow, put vice grips on hose to 2nd good condenser to cut off flow to that one and water still pouring out sea chest. I’m watching the amp meter built into Hatteras electrical panel and it jumps and stays at about same amperage as good condensing unit for the few seconds it does run, so doesn’t look like compressor is locked up. Without proper HVAC tools and know how, think I will have to wait on tech. Will report back what it is when I find out.
    Scott
    1976 43DCFB ,Hull #428, “Exodus”
    Long Island, NY

  8. #8

    Re: A/C Condenser Compressor cycles quickly....

    I would guess next culprit is low refrigerant but you need gauges to check that.

  9. #9

    Re: A/C Condenser Compressor cycles quickly....

    Quote Originally Posted by sgharford View Post
    Not the water flow, put vice grips on hose to 2nd good condenser to cut off flow to that one and water still pouring out sea chest. I’m watching the amp meter built into Hatteras electrical panel and it jumps and stays at about same amperage as good condensing unit for the few seconds it does run, so doesn’t look like compressor is locked up. Without proper HVAC tools and know how, think I will have to wait on tech. Will report back what it is when I find out.
    Here's where it gets fun. Almost all the companies you call will try and sell you an entire new condensing unit from cruisair for almost $6k. But you can get the compressor, not the whole unit, for a few hundred dollars from grainger or other places online, and have it installed in your condensing unit by any ac company for a few hundred more dollars if you're willing to bring it to them. If you don't want to mess with it and want them to come out to the boat, my experience is almost any company will figure out a way to get $1k out of you for an onsite call. But either way you still save like $5k. There's another recent thread where somebody just posted the part numbers and the link to buy the drop-in replacement compressors for most of these units.

  10. #10

    Re: A/C Condenser Compressor cycles quickly....

    I hear what you are saying above. HVAC companies love to protect their craft and I find usually recommend worst case, most expensive fix (ie replacing unit). Even if it's a charge of 1 lb of the banned no where to be found scary ozone depleting R-22 I know I'm going to get hit with a $1,000 invoice. Sad to admit, but I sold commercial HVAC equipment for six years for a major manufacturer, but I don't know how to work on them. The good condenser is original (47 years old) and never been charged, at least in my 15 years of ownership. There has been little reason for me to invest in tools and know how as result. But I am starting to get the itch...
    Scott
    1976 43DCFB ,Hull #428, “Exodus”
    Long Island, NY

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts