To start out went out on sea trial my starboard engine wouldn’t accelerate no power. Went to ck found water in raycors. I drained water. Switched tanks to cockpit tank where port engine is running fine on no problem. I changed raycors primary and secondary. I have nice pink fuel in bowls. Engine starts right up. I can push throttle up and it slowly responds no black smoke. Has no snap. When I sea trial won’t go over 700rpm.
Welcome to the Hatteras Owners Forum & Gallery. Sign Up or Login
+ Reply to Thread
Results 1 to 9 of 9
Hybrid View
-
04-04-2020 02:06 PM #1Registered Member
- Join Date
- Sep 2018
- Posts
- 11
65 Hatteras 16v92 ddec2 1993 power loss water in raycor
-
04-04-2020 06:46 PM #2Senior Member
- Join Date
- Apr 2008
- Posts
- 494
Re: 65 Hatteras 16v92 ddec2 1993 power loss water in raycor
You need to get a DD tech with a diagnostic computer down to the boat. I would advise that you not operate that engine until a full DDEC diagnosis is run. Only harm can come to that engine if operation continues. You will be looking at up to 500 boat bucks to rebuild that unit.
Last edited by kelpy; 04-04-2020 at 06:50 PM.
-
04-04-2020 06:59 PM #3Registered Member
- Join Date
- Sep 2018
- Posts
- 11
Re: 65 Hatteras 16v92 ddec2 1993 power loss water in raycor
Ok thank you
-
04-05-2020 06:57 AM #4
Re: 65 Hatteras 16v92 ddec2 1993 power loss water in raycor
I have the 8v92's w/DDECs, if there are no computer error codes actively coming up, I would continue to trouble shoot the fuel line. Check the fuel pressure display from the DDEC, should be around 40-60psi at idle. If they are low, I would check for clogged fuel line. Run the Fuel Priming Pump for a few minutes and see what the Racor Vacuum gages read....should be about 10-12. If they read higher/lower typically a sign of a clogged filter or plugged line. Given that you just change the filters, I would say plugged line.
Best regards,
--
David
-
04-05-2020 07:47 AM #5Senior Member
- Join Date
- Apr 2008
- Posts
- 494
Re: 65 Hatteras 16v92 ddec2 1993 power loss water in raycor
Excellent point. If your fuel lines are over 10 years old and rock hard, they should be replaced. Every time you touch one of those rock hard lines, the liner is subject to cracking and partially plugging the line. You can check fuel pressure with a mechanical gauge on the engine secondary fuel filter housing where the fuel return line connects. Install the gauge just upstream of the manifold connection. That is the way my engines are configured. YMMV.
-
Re: 65 Hatteras 16v92 ddec2 1993 power loss water in raycor
Check to ensure that the emergency stop plate hasn’t tripped and is shutting off air to that engine.
The engine will perform exactly as you explained if one of them is tripped.