Ok, so after the first couple trips in the boat we have a laundry list of 'to-dos'. A couple of these issues involve 12v products running on a 32v system.
First of all is the windlass. The PO installed a 12v lewmar windlass and installed two batteries in the fwd bilge and a charger in the bow stateroom closet. Well, the batteries are pretty much toast and need replacing.
Personally, rather than replacing those batteries, and maintaining them I'd prefer to either switch to a 32v windlass OR install a voltage regulator that would allow the 12v windlass to run off the boat's 32v.
After looking at the price of a 32v windlass I'm really leaning more toward voltage regulator...
Anyone have any ideas what type of voltage regulator would work for this situation?
Second, we want to install electric downriggers (or at least plugs for them) in the cockpit somewhere. Here we run into the same situation as above, all the downriggers are 12v. So do I have to install more batteries and charger or can I just add a voltage regulator to reduce the voltage?
As a general disclaimer, I'm very ignorant when it comes to the voltage regulators/transformers, just trying to educate myself a little on the subject and hopefully make wise decisions.
Welcome to the Hatteras Owners Forum & Gallery. Sign Up or Login
+ Reply to Thread
Results 1 to 10 of 15
Hybrid View
-
04-23-2018 12:03 PM #1Senior Member
- Join Date
- Jul 2013
- Posts
- 1,188
Voltage transformers/regultors 32v-> 12v, help educate me
Last edited by rustybucket; 04-24-2018 at 01:00 PM.
-
Re: Voltage transformers/regultors 32v-> 12v, help educate me
If the windlass is in good condition, I would leave the system as it is and replace batteries. Just buying the wire and the DC-DC voltage converter may be more expensive than replacing batteries. It is not uncommon on many boats to have battery bank near the windlass. Let’s see what others say. For your downrigger electric it you can buy DCDC Converter on Amazon. FYI, transformers are AC electrical devices only.
Thanks,
Tony
2008 Cheoy Lee Bravo 78 "Bella Sophia"
1989 78' Hatteras CPMY #311 "Bella Sophia" (sold)
2007 Everglades 290cc “Bada Bing” (sold)
2006 Advanced Outdoors 28cc (sold)
2003 Melges 24 "Bada Bing" (sold)
2023 HCB 42 “Bada Bing”
-
04-23-2018 12:55 PM #3Senior Member
- Join Date
- Jul 2013
- Posts
- 1,188
Re: Voltage transformers/regultors 32v-> 12v, help educate me
The 32v wiring is already ran to the windlass. Appears that the boat used to have a 32v windlass. The 12v windlass is in like-new condition. The battery bank is two agm's and would cost me $400-$600 to replace just the batteries.
Anybody think something like this would work for the windlass?
https://www.daygreen.com/products/24...=7091607732257
Specs say it's 100a (windlass should only draw 80ish). I could easily mount the voltage converter in the closet.
If it works I may get the same unit for the cockpit, although it would be quite an overkill for that situation, it would at least leave some room for additions/upgrades.
-
Re: Voltage transformers/regultors 32v-> 12v, help educate me
What model/brand windlass?
Sky Cheney
1985 53EDMY, Hull #CN759, "Rebecca"
ELYC on White Lake--Montague, MI
-
04-23-2018 02:04 PM #5Senior Member
- Join Date
- Jul 2013
- Posts
- 1,188
-
Re: Voltage transformers/regultors 32v-> 12v, help educate me
I think we have the same boat. Were it me, I'd get a couple of Group 31 AGMs. Unless you're a frequent anchorer, they'll last. When they are eventually done you'll typically have plenty of advice notice. Inputing and pulling close to or at full potential of that converter isn't something destined to last. Your 32 volt system is probably putting out a bit more than 35 volts when charging. When it blows, you're done. Guessing at what you have ... have you hauled a 77 lb anchor and 100' of 1/2" chain lately?
Don't know what the down riggers might draw, but you've got a 12 volt generator battery within an easy run to the cockpit. I assume you're running the generator underway.
That make any sense to you?Semper Siesta
Robert Clarkson
ASLAN, 1983 55C #343
Charleston, SC
-
04-24-2018 11:40 AM #7Senior Member
- Join Date
- Jul 2013
- Posts
- 1,188
Re: Voltage transformers/regultors 32v-> 12v, help educate me
Ours is a 1986 52c with 8v92's @ approx 600hp/ea fresh off rebuilds. We have a brand new phasor 21kw gen. The generator battery may be a good option for the cockpit stuff. I wouldn't mind putting in a good agm 31 for the generator and have it run the cockpit too. Thanks for the idea on that, think that will work well.
Currently in place up there in the bow, group 31's agm. While we anchor somewhat frequently, every other weekend or so, 3 or 4 drops per weekend, it's almost always in less than 10' deep water. I have a couple of anchors, still undetermined which is going to be best in the sandy bottoms we anchor in (delta or fluke). All our anchors are 50ish lbs and the chain is 3/8".
I've ordered one of the voltage regulators, the spec sheet actually says max input of 45volts, the page itself says max of 35v. I figure for $100 what do I have to loose. At minimum (if the windlass doesn't burn it up) I can keep it on hand for a spare 12v source. At worse I learn a $100 lesson .
-
Re: Voltage transformers/regultors 32v-> 12v, help educate me
I'm with you. Let us know how that works out on some long pulls if you would.
Semper Siesta
Robert Clarkson
ASLAN, 1983 55C #343
Charleston, SC